Color steel plate is common in the construction industry. It can provide shelter for people and plays a very important role in daily life. How much do you know about its anti-corrosion spraying technology? You know what? The following color steel plate manufacturers will be introduced to you. I hope they can help you.

其防腐涂层能延长彩钢板的使用寿命，而普通油漆只能起到临时表面覆盖的作用，很快就会发生皮肤爆炸和脱落，不能从根本上解决腐蚀问题，防止生锈的发生。八种喷涂技术如下：

The anti-corrosion coating can prolong the service life of the color steel plate, while the ordinary paint can only play the role of temporary surface coverage, and the skin will explode and fall off soon, which can not fundamentally solve the corrosion problem and prevent the occurrence of rust. Eight spraying techniques are as follows:

1.涂料按产品规定的比例配制，搅拌均匀。养护时间应控制在30分钟。施工应在6小时内完成。涂层间隔不得少于24小时，不得超过7天。

1. The coating shall be prepared according to the proportion specified by the product and stirred evenly. The curing time shall be controlled within 30 minutes. The construction shall be completed within 6 hours. The coating interval shall not be less than 24 hours and not more than 7 days.

2.施工用工具应清洁干燥，涂料不得与水、香蕉水、酒精溶剂、汽油等杂质混合。涂层应在准备使用后6小时内喷涂，以防止粘结，造成不必要的损失，增加施工成本。

2. The construction tools shall be clean and dry, and the coating shall not be mixed with water, banana water, alcohol solvent, gasoline and other impurities. The coating shall be sprayed within 6 hours after it is ready for use to prevent bonding, causing unnecessary loss and increasing construction cost.

3.彩钢板厂家建议先用水枪冲洗彩钢板瓦，然后用角磨机、钢丝刷、铁砂布等工具清理基面上的灰尘、污垢、毛刺、水渍、油脂、老化漆层等附着物。

3. The color steel plate manufacturer suggests to wash the color steel plate and tile with a water gun first, and then clean the dust, dirt, burr, water stain, grease, aging paint layer and other attachments on the base surface with angle grinder, steel wire brush, iron sand cloth and other tools.

4.喷涂前，用刷子或压缩空气将格栅表面、角落和凹槽上的灰尘清理干净。

4. Before spraying, clean the dust on the grid surface, corners and grooves with a brush or compressed air.

5.基层表面清理合格后，方可进行喷层施工。

5. The spraying construction can be carried out only after the surface of the base course is cleaned and qualified.

6.涂装施工应无渗漏、无锈粉。

6. The coating construction shall be free of leakage and rust powder.

7.为防止二次污染，基层表面处理后应立即喷涂一次。

7. In order to prevent secondary pollution, the base course surface shall be sprayed once immediately after treatment.

8.在雨、雾、雪和大灰尘的条件下不能进行施工。

8. Construction cannot be carried out under the conditions of rain, fog, snow and heavy dust.

以上就是为大家介绍的有关济南彩钢瓦厂的详细介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以的态度,为您提供服务http://sxhtyz.com

The above is the detailed introduction of Jinan color steel tile factory. I hope it will help you If you have any questions, you are welcome to contact us We will provide you with professional service http://sxhtyz.com